Mason Sand for Patios in Heber Springs, AR

Arkansas Rock Supply handles gravel and aggregate delivery in Heber Springs, AR for two kinds of buyers: contractors building to a written standard and homeowners finishing a patio, walk or drive. Both start in the same place, with SB-2 base.

This is Boston Mountains ground, stony silt loam and clay over sandstone and shale. A patio or pad only holds up when the bedding and base under it are right.

Ground and Conditions in Heber Springs

Across the Boston Mountains, shale beds perch water above the rock. Slopes stay wet and slick long after a rain, and the sandstone above sheds water straight down the hollow.

A flatwork pad on that ground fails at the edges first. Water reaches the bedding, the bedding moves, and the pavers or slab rock over a hollow.

Slope length and gradient drive the erosion here. Runoff on a steep drive cuts ruts and carries surfacing downhill, and saturated shale slopes slump after long rain.

That is why the base course matters more than the surface. SB-2 base is a dense-graded 1 1/2 inch minus crushed stone with the fines left in, so it locks up under a roller instead of shifting.

When you are building to a written spec, the same material is written as Class 7 base, or Class 7 aggregate base course, in city and engineer standards. Ask for it either way and you get the same stone.

Timing matters too. Winter ice and mud on steep drives set the limits, and grading and compaction go best from late spring through fall once the slopes have dried out.

Frost is real on shaded north-facing slopes, which hold it hours longer than the valleys. No statewide frost depth is published; each jurisdiction sets its own line, and the Arkansas residential code requires exterior footings at least 12 inches below undisturbed ground.

Ask the Cleburne County or Heber Springs building official for the local number.

Materials for Heber Springs Projects

Bedding under pavers and flatwork is where the wrong material shows up fastest. Screenings, also called limestone fines, stone screenings or crusher fines, are the Arkansas bedding and joint material for pavers, flagstone and brick.

They pack tight and give you a surface that walks clean. Under a slab or a pool, washed sand, also called concrete sand or river sand, is the bedding and leveling layer.

Mason sand is the other half of the job: brick, block and stone work, paver joints, and play sand. It is finer than screenings and holds a joint line.

Every one of those sits on a compacted base. SB-2 base is the standard Arkansas base for driveways, parking pads, shed and building pads and pipe bedding.

Where a finer dense-graded material is wanted, crusher run binds and compacts the same way. Class 8 base, or 1 inch minus base, is the tighter size of the same idea.

Drainage is the other half of a flatwork job. #57 limestone, also called #57 stone, 57 rock or clean rock, is the washed size for French drains, foundation and pipe drainage and concrete aggregate.

3/4 inch clean limestone does drainage beds, construction entrances and drive surfacing where a washed stone with no fines is wanted. 3/8 inch crushed stone covers fine drainage, pipe bedding and paver joints.

For decorative work, Natural Pea Gravel goes on walkways, play areas and dog runs. River gravel, or creek gravel, fills beds, borders and dry creek beds, and large river rock suits heavier decorative work and light bank protection.

Rip rap armors banks and slopes on creeks and lake edges, culvert outlets and ditch checks. Fill dirt raises low ground and builds a pad up out of the wet before a base course goes on.

Topsoil, usually screened, covers lawns and bed prep. Garden soil fills raised beds and planting areas, and shredded mulch holds moisture through an Arkansas summer.

Delivery to Heber Springs and the Surrounding Area

Order online and choose your quantity by the ton or by the yard. Each product page has a calculator if you want to size the load before checkout.

Pick a delivery date at checkout and a dump truck tips the load on site. Bulk material arrives in one pile, so have the spot clear before the truck gets there.

Heber Springs sits in Cleburne County, and delivery covers the county, including Tumbling Shoals, Quitman, Wilburn, Drasco and Concord.

Order SB-2 Base and Bedding Material in Heber Springs

Start with the calculator on the product page and settle your quantity, then order online for delivery in Heber Springs. Arkansas Rock Supply delivers SB-2 base, screenings, sand and stone by the ton or yard, and a truck tips it on site.